Researchers produce new egg pasteurization method

PPPL engineer Chris Brunkhorst displays an egg while a computer image simulates the levels of RF power that different parts of an egg absorbed during an experiment. Credit: Elle Starkman/PPPL Office of Communications Researchers at the Princeton Plasma Physics Laboratory…

PPPL engineer Chris Brunkhorst displays an egg while a computer image simulates the levels of RF power that different parts of an egg absorbed during an experiment. Credit: Elle Starkman/PPPL Office of Communications

Researchers at the Princeton Plasma Physics Laboratory (PPPL) and the U.S. Department of Agriculture (USDA) have developed a novel technique and device for rapidly pasteurizing eggs in the shell without damaging the delicate egg white. The process could lead to a sharp reduction in illnesses caused by egg-borne salmonella bacteria, a widespread public health concern.

The new method uses radio frequency (RF) energy to transmit heat through the shell and into the yolk while the egg rotates. Streams of cool water simultaneously flow over the egg to protect the white. Researchers then bathe the egg in hot water to pasteurize the white and finish pasteurizing the yolk.
The aim is to produce a pasteurized egg that is “hardly discernible from a fresh, nonpasteurized egg,” said David Geveke, lead scientist, at the USDA Agricultural Research Service in Wyndmoor, Pa. His laboratory teamed up with PPPL engineer Christopher Brunkhorst, an expert in RF heating, to develop the device.
The roughly shoebox-size prototype can pasteurize shell eggs in about one-third of the time that current methods require, Geveke said. Such methods place the eggs in heated water for about an hour and visibly change the appearance of the egg white. The RF process, by contrast, maintains the egg white’s transparency.
Federal regulations require pasteurization of raw liquid egg products used in commercially sold dishes such as ice cream, eggnog, sauces and dressings, but no similar rule covers eggs in the shell. Fewer than one-half of 1 percent of all shell eggs produced for retail sale in the United State are pasteurized, according to an estimate by the Food Safety and Inspection Service of the USDA.
While only a small fraction of shell eggs may harbor salmonella, the public health risk posed by consumption of raw or undercooked eggs stems from the fact that millions of eggs are eaten each day. The hazard is greatest for people with weakened immune systems, including the very young, the very old and hospital patients. The USDA estimates that pasteurizing all U.S.-produced shell eggs could reduce the number of egg-borne salmonella illnesses by up to 85 percent, or more than 110,000 cases a year.
Brunkhorst, a 30-year veteran of PPPL and member of the lab’s engineering and scientific staff, has helped design large RF heating systems for fusion energy experiments. He began assisting the Wyndmoor-based project in 2010 after working with the USDA on previous ventures.
“It’s turned out to be a really good fit,” said Brunkhorst, who co-invented the pasteurization device with Geveke and USDA engineering technician Andrew Bigley. They benefited from joining forces because pasteurizing shell eggs can be a tricky task. “You have to raise the temperature high enough to kill bacteria, but not high enough to cook the egg,” Brunkhorst said. “You’re really threading the needle on this.”
Further complicating the process is the fact that the egg white is more sensitive to overheating than the yolk is. But the RF energy must pass through the white in order to reach the yolk, which requires a higher temperature to pasteurize.
The system works through what is known as “ohmic heating,” in which the RF energy creates an electric current that produces heat inside the egg. Food-processing firms employ a similar system for heating, baking and drying a wide range of products.
Brunkhorst brought test equipment into his own kitchen to experiment with RF frequencies that the researchers then tried out in the Wyndmoor laboratory.
The USDA prototype, which the agency has applied to patent, couples RF energy through the shell by placing electrodes against opposite sides of the egg. The egg rests on rollers that turn it to distribute the heat and cooling water evenly. “The goal is to reach a certain temperature for a certain time,” Brunkhorst said.
Researchers then take a sample of the egg and do a bacteria count. “We’ve proven the effectiveness analytically,” Brunkhorst said.
The USDA is seeking a licensee to commercialize the product. Potential partners include egg producers and manufacturers of egg-processing equipment.
“We have received quite a bit of interest from industry,” Geveke said. “We expect to have a partner in the next few months.”

Explore further:

What are the risks when hens lay their eggs on the floor?

Provided by

Princeton Plasma Physics Laboratory

view popular

5 /5 (2 votes)

Related Stories

Study eyes egg quality and composition

Jul 07, 2010

( — There’s no substantial quality difference between organically and conventionally produced eggs. That’s one of a number of findings in an Agricultural Research Service (ARS) study examining various aspects …

Extension food-safety specialist offers information on safely handling eggs

Aug 31, 2010

No matter where you get your eggs, a few basic food safety steps can keep you, your family, or the customers at your business safe. That’s according to South Dakota Cooperative Extension Food Safety Specialist Joan Hegerfeld-Baker, …

What are the risks when hens lay their eggs on the floor?

Jul 30, 2013

Hens usually prefer to lay their eggs in nests but it is not unusual for some eggs to be laid on the floor of the hen house or on the ground and in some cases the incidence of floor eggs can be quite high. …

Cooling system may build eggs’ natural defenses against salmonella

Jun 21, 2011

( — Once eggs are laid, their natural resistance to pathogens begins to wear down, but a Purdue University scientist believes he knows how to rearm those defenses.

Rapidly cooling eggs can double shelf life, decrease risk of illness

Jun 11, 2012

Taking just a few seconds to cool freshly laid eggs would add weeks to their shelf life, according to a Purdue University study.

Severe egg allergy? There’s now a flu shot for you

Jun 20, 2013

People with serious egg allergies may no longer have to worry about flu shots.

Recommended for you

Risk to consumers from fungal toxins in shellfish should be monitored

3 hours ago

To protect consumers, screening shellfish for fungal toxins is important, say scientists.

Researchers develop new system to better study behavior, cell function

9 hours ago

A team of researchers led by Charles D. Nichols, PhD, Associate Professor of Pharmacology at LSU Health Sciences Center New Orleans, has successfully translated a new technology to better study behaviors and cellular function …

Identification of a plant-specific nanomachine regulating nuclear movement

13 hours ago

A group led by Professor Ikuko Hara-Nishimura (Department of Botany, Graduate School of Science) revealed the molecular mechanism underlying nuclear movement in plants.

Protein lifetime and the stability of cell structures

Sep 04, 2013

( —The ability of a cell to move, replicate, and recast itself according to the needs of the organism which it serves, comes at it price. The extreme flexibility of cells takes its origin from …

Novel biological function of polyester in insect-bacterium symbiosis

Sep 04, 2013

Researchers from AIST have demonstrated that an intestinal symbiotic bacterium, which has beneficial effects on the growth and reproduction of the bean bug (Riptortus pedestris) known as a soybean pest, accumulates …

The ‘weakest link’ in the aging proteome

Sep 03, 2013

Proteins are the chief actors in cells, carrying out the duties specified by information encoded in our genes. Most proteins live only two days or less, ensuring that those damaged by inevitable chemical …

User comments : 0

More news stories

Unravelling the secrets of maleness

New research has identified the key to becoming male is an enzyme that “unravels” DNA to trigger male development of the embryo, a discovery that may give greater insight into intersex disorders.

Certification of aquaculture: One of the strategies to sustainable seafood production

Certification of products from aquatic farming – aquaculture – is contributing to sustainable production, but it also has serious limits. Therefore it should be seen as one approach among many for steering aquaculture toward …

Protecting 17 percent of Earth’s land could save two-thirds of plant species

Protecting key regions that comprise just 17 percent of Earth’s land may help preserve more than two-thirds of its plant species, according to a new Duke University-led study by an international team of scientists.

Disease-causing genes spread easily in emerging lethal fungus infection

A rare, emerging fungal disease that is spreading throughout Canada and Northwestern USA can easily pass its deadly genes to related fungal strains within the species but less readily to more distant relatives, …

Newly discovered tiger shark migration pattern might explain attacks near Hawaii

The migration of mature female tiger sharks during late summer and fall to the main Hawaiian Islands, presumably to give birth, could provide insight into attacks in that area, according to a University of Florida scientist.

Do glial connectomes and activity maps make any sense?

(Medical Xpress)—”If all you have is a hammer, everything looks like a nail.” This so-called “law of the instrument” has shaped neuroscience to core. It can be rephrased as, if all you have a fancy voltmeter, …

Interstellar winds buffeting our solar system have shifted direction

Scientists, including University of New Hampshire astrophysicists involved in NASA’s Interstellar Boundary Explorer (IBEX) mission, have discovered that the particles streaming into the solar system from …

New model of Earth’s interior reveals clues to hotspot volcanoes

Scientists at the University of California, Berkeley, have detected previously unknown channels of slow-moving seismic waves in Earth’s upper mantle, a discovery that helps explain “hotspot volcanoes” that …

Report: US military cracked most online encryption (Update)

The National Security Agency, working with the British government, has secretly been unraveling encryption technology that billions of Internet users rely upon to keep their electronic messages and confidential …

Made-to-order materials: Engineers focus on the nano to create strong, lightweight materials

( —The lightweight skeletons of organisms such as sea sponges display a strength that far exceeds that of manmade products constructed from similar materials. Scientists have long suspected that …